93 Ford Aerostar alternator light is on you had the alternator check and it comes out good what else should you check?

1. What fuse controls the alternator?
2. What can mimic a bad alternator?
3. How do I know if my alternator diode is bad?
4. Can a blown fuse cause alternator problems?
5. Why does my alternator light stay on?
6. Where is the voltage regulator installed?
7. What are the signs of a bad stator?
8. Does low voltage mean bad alternator?
9. Will an alternator still charge with a bad diode?

What fuse controls the alternator?

There are 2 fuses for the alternator. One is usually a fusable link (wire) for connecting the stator diodes to the battery, and a lower value fuse (10 to 30 amp) for protecting the field (rotor).

What can mimic a bad alternator?

Testing at the Battery

Start by checking your battery terminals. Loose or heavily corroded terminals can mimic the effects of a bad alternator.

How do I know if my alternator diode is bad?

Usually, a bad alternator diode will cause your headlights or instrument panel lights to flicker or dim and, sometimes, drain battery power overnight, or in minutes. * To check for a possible bad alternator diode, switch your voltmeter to a low setting on the AC (alternating current) voltage scale.

Can a blown fuse cause alternator problems?

A blown alternator fuse will prevent the charging system from working properly, leading to a variety of problems that can mimic a bad alternator.

Why does my alternator light stay on?

When the light stays on, it indicates that the computer has detected an issue with the charging system. ... An alternator that is on its way out may cause this warning light to flash when there is a high demand on the battery.

Where is the voltage regulator installed?

The regulator can be mounted inside or outside of the housing. A wiring harness will connect the regulator to the alternator if it is mounted outside. The alternator's field current is controlled by the voltage regulator.

What are the signs of a bad stator?

The most obvious symptoms of a bad motorcycle stator include no spark, weak spark, or intermittent spark (also known as misfiring). Hard starts and a poorly running engine can also be clues that your stator needs to be rebuilt or replaced.

Does low voltage mean bad alternator?

If the charging voltage is low, or the alternator isn't putting out enough current to keep up with the electrical loads that are placed upon it, don't automatically assume the alternator is bad and needs to be replaced (unless you're bench testing the unit out of the vehicle).

Will an alternator still charge with a bad diode?

Bad diodes are a common cause of alternator failure. ... If only one or two diodes have failed, the alternator may still produce enough current to meet the vehicle's electrical needs, but it may not be enough to keep up with higher loads or keep the battery fully charged. This could cause the battery to run down over time.