Where do you gap a spark plug on a 1998 Ford Expedition?

1. What is the spark plug gap on a Ford Expedition?
2. Do all spark plugs come pre-gapped?
3. How do you gap a spark plug without a tool?
4. What is the spark plug gap on a 99 Ford Expedition?
5. What year Fords have the spark plug problem?
6. How many spark plugs are in an expedition?
7. Does the Ford Expedition have spark plug wires?
8. What happens if spark plugs are gapped too much?
9. What happens if your spark plug gap is too small?
10. What does a smaller spark plug gap do?

What is the spark plug gap on a Ford Expedition?

The proper gap for spark plugs is always listed on the underhood emissions label. The gap for 2v 4.6L and 5.4L engines is . 054 to . 056 inches.

Do all spark plugs come pre-gapped?

Do Spark Plugs Always Have to Be Gapped? Not always. In the past, it was necessary to gap spark plugs, but today spark plugs are usually pre-gapped. It is advisable to double check that the gap is correctly set to the vehicle's recommended setting when installing spark plugs.

How do you gap a spark plug without a tool?

All you need to do is slide the spark plug electrode opening into the gap opener and gently move it over to the smallest side of the gapper. Once it hits the 0.02” area, press the electrode down until it's flush on each end of the gapper.

What is the spark plug gap on a 99 Ford Expedition?

You will find the exact gap size for the 1999 Ford Expedition in your owner's manual. On the 4.6 litre V-8 engine, the gap size will be 0.059. Once you have set the gaps, install each spark plug in the engine block using your spark plug wrench.

What year Fords have the spark plug problem?

Design News readers have commented about having to lift engines or make holes in the car body to change spark plugs. This article describes a particularly frustrating spark plug issue with the 2004-2008 Ford 4.6-liter, 5.4-liter, and 6.8-liter 3-valve "modular" engines.

How many spark plugs are in an expedition?

Even if only one spark plug is found to be faulty, they should always be replaced in sets. Most engines will require 4,6, or 8 spark plugs.

Does the Ford Expedition have spark plug wires?

Shop Ford Expedition Replacement Spark Plug Wires

Your Ford Expedition's spark plug wires carry voltage from the ignition coil to the engine's spark plugs.

What happens if spark plugs are gapped too much?

Excessive spark plug gap results when the voltage has too far to travel. ... Excessive plug gap also results in cylinder misfiring, a possible no-start condition, wet, black or fouled plugs, engine hesitation and rough idle. Excessive spark plug gap also happens as result of normal electrode wear and age.

What happens if your spark plug gap is too small?

The Spark-Plug Gap

One of the key factors that makes a spark plug work well, or not, is the size of the gap between the electrodes. If the gap is too small, the spark will likely be too weak and cause the engine to run poorly or with poor efficiency.

What does a smaller spark plug gap do?

A smaller gap will yield a short, intense spark and will usually make the engine real responsive. A wide gap creates a longer spark arc but without sufficient "juice" from your ignition system, (including amps), it can be weak and yellow in color.